Product ID:MIL-PRFL-3572B GRADE B MEDIUM
MSDS Date:07/31/2001
FSC:9150
NIIN:00-235-5584
Status Code:A
MSDS Number: CLJRJ

Emergency Phone: 800-255-3924 (CHEM-TEL)

Info Phone: 810-984-4213

Preparer: DEBRA SULLIVAN

Cage: 03432

Telephone: 810-984-4213

Cage: 03432

GRAPHITE

CAS: 7782-42-5

RTECS: MD9659600

OSHA PEL see Table Z-3

ACGIH TLV: 2 MG/M3

MINERAL OIL

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3 (OIL MIST)

LD50 LC50 Mixture:NOT PROVIDED
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: NOT EXPECTED TO CAUSE
IRRITATION UNDER NORMAL CONDITIONS OF USE. SYMPTOMS OF TEMPORARY
EYE IRRITATION AND REDNESS MAY RESULT UPON DIRECT CONTACT/WHEN
EXPOSED TO HIGH MIST LEVELS IN POORLY VENTILATED AREAS. SKIN:
SHORT TERM CONTACT IS NOT EXPECTED TO CAUSE IRRITATION.
PROLONGED/REPEATED EXPOSURE MAY RESULT IN IRRITATION, REDNESS. IN
SEVERE CASES, MAY RESULT IN DERMATITIS, ITCHING, DRYNE SS, CRACKING
AND/OR INFLAMMATION. INHALATION: THIS PRODUCT HAS LOW VOLATILITY.
EXPOSURE TO HIGH MIST LEVELS MAY CAUSE IRRITATION AND DIFFICULTY
BREATHING. INGESTION: MAY CAUSE SLIGHT STOMACH IRRITATIO N AND
DISCOMFORT.
Explanation of Carcinogenicity:THIS PRODUCT IS NOT LISTED AS A KNOWN OR
SUSPECTED CARCINOGEN BY IARC, OSHA, OR THE NTP.
Effects of Overexposure:EYE: SYMPTOMS OF TEMPORARY EYE IRRITATION AND
REDNESS MAY RESULT UPON DIRECT CONTACT/WHEN EXPOSED TO HIGH MIST
LEVELS IN POORLY VENTILATED AREAS. SKIN: PROLONGED/REPEATED
EXPOSURE MAY RESULT IN IRRITA TION, REDNESS. IN SEVERE CASES, MAY
RESULT IN DERMATITIS, ITCHING, DRYNESS, CRACKING AND/OR
INFLAMMATION. INHALATION: EXPOSURE TO HIGH MIST LEVELS MAY CAUSE
IRRITATION AND DIFFICULTY BREATHING. INGEST ION: MAY CAUSE SLIGHT
STOMACH IRRITATION AND DISCOMFORT.
Medical Cond Aggravated by Exposure:GRAPHITE, WHEN SUSPENDED IN LIQUID,
IS NOT EXPECTED TO AGGRAVATE ANY EXISTING MEDICAL CONDITIONS.
PREEXISTING PULMONARY DISORDERS SUCH AS EMPHYSEMA, MAY BE
AGGRAVATED BY PROLONGED EXPOSURE TO ITS DUST.

First Aid:EYE: UPON DIRECT CONTACT, HOLD EYELIDS OPEN AND FLUSH WITH A
GENTLY STREAM OF WATER FOR AT LEAST 15 MINUTES. IF IRRITATION IS
DUE TO EXPOSURE TO MIST/VAPORS, REMOVE TO FRESH AIR. IF SYMPTOMS
PERSIST, CONTACT A PHYSICIAN. SKIN: REMOVE PRODUCT FROM SKIN BY
WASHING WITH A MILD SOAP AND WATER. IF SYMPTOMS PERSIST, CONTACT A
PHYSICIAN. INGESTION: IF SMALL AMOUNTS ARE INGESTED, FIRST AID
MEASURES ARE NO T LIKELY TO BE NECESSARY. IF SYMPTOMS OCCUR AND
VICTIM IS CONSCIOUS, DILUTE STOMACH CONTENTS WITH 2 GLASSES OF
WATER/MILK. DO NOT INDUCE VOMITING WITHOUT MEDICAL SUPERVISION. IF
SYMPTOMS PERSIST, GET MEDICAL ATTENTION.

Flash Point Method:COC
Flash Point:=148.9C, 300.F
Autoignition Temp:Autoignition Temp Text:N/E
Extinguishing Media:IN ACCORDANCE WITH NFPA GUIDANCE, DRY CHEMICAL,
FOAM, OR CO2 FIRE EXTINGUISHERS ARE ALL ACEPTABLE.
Fire Fighting Procedures:EMERGENCY RESPONDERS IN THE DANGER AREA SHOULD
WEAR BUNKER GEAR AND SELF-CONTAINED BREATHING APPARATUS FOR FIRES
BEYOND THE INCIPIENT STAGE. NOTE THAT WHILE WATER FOG EXTINGUISHERS
ARE ALSO ACCEPTABLE , DO NOT APPLY A DIRECT STREAM OF WATER INTO
BURNING PRODUCT.
Unusual Fire/Explosion Hazard:NONE KNOWN

Spill Release Procedures:WEAR APPROPRIATE PERSONAL PROTECTIVE
EQUIPMENT. IF POSSIBLE SAFELY CONTAIN SPILL WITH DIKES. PREVENT
SPREADING. ELIMINATE IGNITION SOURCES. PREVENT FROM ENTERING
SEWERS/WATERWAYS. LARGE VOLUME MAY BE TRANSFERRED TO AN
APPROPRIATE CONTAINER FOR PROPER DISPOSAL. SMALL VOLUMES OR
RESIDUES MAY BE SOAKED UP WITH ABSORBENTS. SPILL RESPONSE MATERIALS
SHOULD BE COLLECTED FOR PROPER DISPOSAL.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
PROTECT PRODUCT QUALITY BY STORING INDOORS AND AWAY FROM EXTREME
TEMPERATURES. CLOSE ALL CONTAINERS WHEN NOT IN USE.
Other Precautions:AS WITH ANY INDUSTRIAL CHEMICAL, HANDLE PRODUCT IN A
MANNER THAT MINIMIZES EXPOSURE TO PRACTICAL LEVELS. WEAR PROTECTIVE
EQUIPMENT IF NEEDED. OPEN CONTAINERS SLOWLY TO RELIEVE ANY
PRESSURE. FOLLOW ALL OTHER STANDARD INDUSTRIAL HYGIENE PRACTICES.
EMPTY CONTAINERS MAY CONTAIN PRODUCT RESIDUE. OBSERVE SAFETY
PRECAUTIONS.

Respiratory Protection:AS RESPIRATOR MAY BE WORN TO REDUCE EXPOSURE TO
VAPORS, DUST, OR MIST. SELECT A NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR THE TYPE AND PHYSICAAL CHARACTER OF THE AIRBORNE
MATERIAL. A SELF-CONTAIN ED BREATHING APPARATUS IS RECOMMENDED IN
ALL SITUATIONS WHERE AIRBORNE CONTAMINANT CONCENTRATION IS UNKNOWN.
COMPLY WITH OSHA STANDARD 29 CFR 1910.134.
Ventilation:NORMAL GENERAL VENTILATION IS ADEQUATE. IT IS RECOMMENDED
THAT VENTILATION BE DESIGNED IN ALL INSTANCES TO MAINTAIN AIRBORNE
CONCENTRATIONS AT LOWEST LEVELS.
Protective Gloves:OIL OR CHEMICAL RESISTANT GLOVES SUCH AS BUTYL OR
NITRILE ARE RECOMMENDED
Eye Protection:CHEMICAL SAFETY GLASSES WITH SIDE SHIELD. CHEMICAL
GOGGLES OR FULL FACE SHIELD
Other Protective Equipment:SELECTION OF PERSONAL PROTECTIVE EQUIPMENT
SHOULD BE BASED UPON THE ANTICIPATED EXPOSURE AND MADE IN
ACCORDANCE WITH OSHA'S PERSONAL PROTECTIVE EQUIPMENT STANDARD FOUND
IN 29 CFR 1910 SUBPART 1.
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
ABBREVIATION: N/A = NOT APPLICABLE. N/AV = NOT AVAILABLE. N/K =
UNKNOWN. N/P = NOT PROVIDED. N/R = NOT RELEVANT. N/D = NOT
DETERMINED. N/E = NOT ESTABLISHED. CNS = CENTRAL NERVOUS SYSTEM. GI
= GASTROI NTESTINAL. SCBA = SELF CONTAINED BREATHING APPARATUS.

HCC:V6
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:NOT PROVIDED
Melt/Freeze Pt:M.P/F.P Text:NOT PROVIDED
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:NOT PROVIDED
Spec Gravity:0.910
Viscosity:NOT PROVIDED
Evaporation Rate & Reference:NOT PROVIDED
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK LIQUID - MILD PETROLEUM ODOR
Percent Volatiles by Volume:NOT PROVIDED
Corrosion Rate:NOT PROVIDED

Stability Indicator/Materials to Avoid:NO
THIS PRODUCT IS INCOMPATIBLE WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID CONTACT WITH INCOMPATIBLE MATERIALS
AND EXPOSURE TO EXTREME TEMPERATURES.
Hazardous Decomposition Products:A COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID, PARTICULATES AND GASES EVOLVE WHEN MATERIAL BURNS.
COMBUSTION PRODUCTS MAY INCLUDE: OXIDES OF CARBON, INCOMPLETELY
BURNED HYDROCARBONS AS FUMES AND SMOKE.

Waste Disposal Methods:ENSURE THAT COLLECTION, TRANSPORT, TREATMENT,
AND DISPOSAL OF WASTE PRODUCT, CONTAINERS AND RINSATE COMPLIES WITH
ALL APPLICABLE LAWS AND REGULATIONS. NOTE THAT USE, MIXTURE,
PROCESSING, OR CONTAMINAT ION OF THE PRODUCT MAY CAUSE THE MATERIAL
TO BE CLASSIFIED AS A HAZARD WASTE. THE USER/OWNER MUST DE TERMINE
IF WASTE IS REGULATED AS A HAZARDOUS WASTE

Toxicological Information:NO FURTHER TOXICOLOGICAL DATA KNOWN.

======================================================================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:ECOTOXICOLOGICAL INFORMATION: THIS PRODUCT HAS NOT BEEN
EVALUATED FOR ECOTOXICITY. AS WITH ANY INDUSTRIAL CHEMICAL,
EXPOSURE TO THE ENVIRONMENT SHOULD BE PREVENTED AND MINIMIZED
WHEREVER POSSIBLE. EN VIRONMENTAL FATE: NO DATA AVAILABLE FOR
BIODEGRADATION.

Transport Information:NOT REGULATED.

SARA Title III Information:SARA 313: THIS PRODUCT CONTAINS NONE OF THE
SUBSTANCES SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF
TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF
1985 AND 40 CFR PART 372 . CLEAN WATER ACT / OIL POLLUTION ACT:
THIS PRODUCT CONTAINS MINERAL OIL AND IS SUBJECT TO REGULATION BY
SECTION 311 OF THE CLEAN WATER ACT AND OIL POLLUTION ACT. RELEASES
OF THE PRODUCT INTO OR LEADI NG TO SURFACE WATERS MUST BE REPORTED
TO THE NATIONAL RESPONSE CENTER, 800-424-8802.
Federal Regulatory Information:CERCLA REPORTABLE QUANTITY: NONE. TOXIC
SUBSTANCE CONTROL ACT : THE COMPONENTS OF THIS PRODUCT ARE LISTED
ON THE TSCA INVENTORY.
State Regulatory Information:STATE REGULATIONS: THIS PRODUCT CONTAINS
MINERAL OIL, AND AS USED, MAY BE REGULATED BY STATE USED OIL
REGULATIONS. CHECK WITH THE APPROPRIATE STATE AGENCY TO DETERMINE
WHETHER SUCH A REGULATION EXISTS .